Transcript

116 Chiang Mai J. Sci.

2011; 38(1)

Chiang Mai J. Sci. 2011; 38(1) : 116-125
www.science.cmu.ac.th/journal-science/josci.html
Contributed Paper

Effects of Varieties, Heat Pretreatment and UHT
Conditions on the Sugarcane Juice Quality
Weerachet Jittanit*, Somsak Wiriyaputtipong, Hathainid Charoenpornworanam,
and Sirichai Songsermpong
Department of Food Science and Technology, Faculty of Agro-Industry, Kasetsart University,
Bangkok 10900, Thailand.
*Author for correspondence; e-mail: [email protected]

Received: 6 November 2009
Accepted: 7 May 2010

ABSTRACT
In this work, the effects of sugarcane varieties, heat pretreatment methods and UHT
conditions on the quality of sugarcane juice were investigated. The aim was to attain the
background information that is useful for the production of high quality UHT sugarcane
juice. The experimental results indicated that the sugarcane Suphan Buri 50 variety is more
suitable for juice production than Singapore variety in aspects of total solid and consumer
preference. Furthermore, it appeared that both the microwave heating for 5 minutes by
frequency 2,450 MHz at 850 W and the blanching sugarcane in hot water at 80oC for
5 minutes could inactivate the peroxidase enzyme at the comparable level. Nevertheless, the
blanching was preferred due to its ease of control, lower energy and equipment cost. In
addition, if F0 > 4 is demanded, the UHT sterilization at 140oC and holding for 4 seconds
could maintain the sugarcane flavors and provide the more favorable juice than those of
o
135 C for 10 seconds.

Keywords: sugarcane juice, blanching, microwave, UHT, sterilization.

1. INTRODUCTION
Sugarcane (Saccharum officinarum L.) is one is limited because of its rapid quality
of the most important crops in the world deterioration [2-4].
especially for the tropical countries. Most of The Ultra-High Temperature (UHT)
them are used for the sugar and alcohol processing is an attractive technique to extend
production. Fresh sugarcane juice is a popular the shelf-life and raise the consumer safety
beverage in many countries such as China, while maintaining the fresh quality of
Malaysia and Thailand due to its taste and sugarcane juice. In the UHT juice production,
cheap price. Apart from that in the Indian the selections of sugarcane variety and the
systems of medicine, it has been used to cure pretreatment are vital. Tangpremsri et al. [5]
jaundice and liver-related disorders [1]. pointed out that the sugarcane variety Suphan
Nevertheless, the marketing of sugarcane juice Buri 50 provided the mean juice yield 1.3
Chiang Mai J. Sci. 2011; 38(1) 117

times higher than the widely grown variety, varieties grown in the central region of
Singapore. Besides, the juice from Suphan Buri Thailand were used in this study. The samples
50 was fine color (green yellow), tasty and were weighed, manually peeled, cut, cleaned
o
10% higher oBrix than those of Singapore and then blanched in hot water at 80 C for 5
variety. To stabilize the fruit juice quality during minutes. After that, the samples were squeezed
processing and storage, the pretreatments like by the “NHY” rolling squeezer motor 0.25 HP
blanching in hot water and/or addition of 220 V 50 Hz and screened the solid particles
antioxidant agents are commonly applied by the filter bag. The juices from both varieties
[6,7]. These pretreatments aim to inactivate were compared in terms of total solid,
the enzymes that cause the color, sensorial and pH, color and consumer acceptance. The
nutritional changes in the fruit and vegetable descriptions of the juice quality determination
products during processing and storage and the evaluation of consumer acceptance
[8-13]. Qudsieh et al. [14] pointed out that the are presented in Section 2.4. The result of
key enzyme related to the browning of varieties comparison would justify the
sugarcane juice was the polyphenol oxidase sugarcane variety used in the following steps.
that reacted with phenolic compounds. Mao
et al. [4] showed that the blanching of 2.2 Heat Pretreatments
sugarcane stems in boiling water for 5 minutes After the variety determination, the
before squeezing and addition of 0.1% chosen sugarcane variety was exposed to the
ascorbic acid could effectively prevent the comparison between the two heat pretreat-
browning and reduce the enzyme activities in ment options, (1) blanching in hot water at
o
the fresh sugarcane juice. Although the thermal 80 C for 5 minutes and (2) microwave heating
resistance of polyphenol oxidase is dependent for 5 minutes using “SHARP” microwave
on its origin or the product types, some oven model R-7A56 at frequency 2,450 MHz,
researchers claimed that in most cases solely 850 W and setting convective air temperature
o
short exposures of fruit or vegetable at 250 C. These two pretreatments were
products to the temperatures between 70 compared because the hot water blanching is
o
and 90 C were adequate for partial or a conventional method that has the advantages
complete inactivation of the polyphenol in aspects of controllability, low energy and
oxidase [10, 15]. equipment cost [16] while the microwave
Owing to the lacking of research in the heating is a new approach that was proposed
area of sugarcane juice processing, the effects to reduce enzyme activities in many studies
of 3 parameters comprising with sugarcane due to its penetration depth and fast heating
varieties, heat pretreatment methods and UHT rate [8, 13, 17]. The main function of the heat
conditions on the quality of sugarcane juice pretreatments in this work was to diminish
were investigated. The aim was to obtain some the enzyme activities that normally cause
useful information for the UHT sugarcane quality deteriorations of sugarcane juice such
juice production. as degreening and/or browning during
processing and storage. The experiments for
2. MATERIALS AND METHODS each pretreatment were carried out at least 2
2.1 Comparison between Sugarcane replications. The juices squeezed from the
Varieties samples pretreated by these two options were
Samples of freshly harvested sugarcane exposed to the peroxidase activity test and
of the “Suphan Buri 50” and “Singapore” sensory evaluation. Also, they were measured
118 Chiang Mai J. Sci. 2011; 38(1)

the total solid, pH and color. Moreover, the conducted on the same day for each
fresh juice squeezed from the non-pretreated experiment. As generally recognized, the
sugarcane stems was exposed to the peroxidase process lethality (F0) is the most important
activity test. However, the pH, color and total parameter that can indicate the level of the
solids measurement and the sensory test were sterilization process and consequently
not conducted for this sample because its the microbiological risk of sterilized food
quality attributes were unstable and rapidly [18-22]. F0 is defined as the time (seconds) at
o
changed along the time due to the enzyme a reference temperature (121.1 C) to which
activities and high microbial growth rate. the process is equivalent [19]. It was calculated
from the temperature history of the sterili-
2.3 UHT Sterilization zation process by integration of the following
After realizing the proper variety and heat equation over time (t) [20-22]:
pretreatment for sugarcane juice preparation,
the UHT sterilization was carried out using
the lab-scale “MicroThermics” UHT/HTST Similar to the common sterilization of
machine model “Lab 25 EHV Hybrid”. The food, the target microorganism of the UHT
schematic diagram of the UHT process is sterilization in this work was Clostridium
o
illustrated in Figure 1. In the UHT machine, botulinum; hence, the z value of 10 C was
there were Type-T thermocouples installed at applied in eq. (1) [21,22]. The F0 4 was
various positions for measuring the juice specified for the UHT sterilization in this study
temperatures. Prior to the UHT experiments, in order to slightly beyond a minimum
the total solid of sugarcane juice was adjusted requirement (F0 3) for the low-acid food
o
to 12 Brix by adding the distilled water so that was recommended by Lewis [18]. There
that the raw samples for all experimental runs were 4 conditions for the UHT experiments
were in the same condition. The fresh juice as detailed in Table 1. The UHT experiments
preparation and the UHT sterilization were were conducted without replication.

Figure 1. A schematic diagram of the UHT process.
Chiang Mai J. Sci. 2011; 38(1) 119

Table 1. The conditions of UHT experiments.
UHT condition
Run no. Raw sample Sterilization
Holding time (s)
temperature (oC)
1 Fresh sugarcane juice 140 4
2 Fresh sugarcane juice added with a
sugar flavor 140 4
3 Fresh sugarcane juice 135 10
4 Fresh sugarcane juice added with a
sugar flavor 135 10

The UHT processed juices were aseptically content, pH, color and peroxidase activity test
filled in the clean fill hood and kept in the were done in three replications. The software
sterilized glass containers for sensory package Statistica 5.5 StatSoftTM (supplied by
evaluation and the determination of total StatSoft, Inc. Tulsa, OK 74104 USA) was used
solid, pH and color. The sensory evaluation for the analysis of variance (ANOVA) and a
and the quality determination were conducted Duncan’s multiple range test in the statistical
within one week after the production of UHT analysis.
samples.
3. RESULTS AND DISCUSSION
2.4 Quality Determination The results of comparing the total solid,
The total solid content, pH and color of pH, color and sensory evaluation (by 26
the sugarcane juice were measured by panelists) between Singapore and Suphan Buri
“ATAGO” hand refractometer, “JENCO” 50 varieties in aspect of flavor are presented
pH meter and “Minolta” color meter model in Table 2. It appeared that the mean total
CM-3500d respectively. The sensory was solid of juice from Suphan Buri 50 was
o
evaluated using Hedonic scale test by at least 19.6 Brix, which was significantly higher than
o
20 panelists who were the students in the that of the Singapore variety (12.1 Brix).
department of Food Science and Technology, However, the average pH value of juices from
Kasetsart University. The peroxidase activity both varieties were insignificant different
test was conducted by putting the 5 drops of (average pH = 5.0 and 5.3 for Suphan Buri
the juice sample into the enzyme test hole 50 and Singapore respectively). This went
and then 2 drops of both the solutions of along with the result of Tangpremsri et al. [5]
guaiacal 0.5% and hydrogen peroxide 0.3% who claimed that the total solid of juice from
respectively [23]. After 30 s, the sample color Suphan Buri 50 was higher than Singapore.
would change and be recorded. The Furthermore, the colors of the two varieties
peroxidase enzyme is more heat stable than were significantly different. The color of juice
polyphenol oxidase [11]. Therefore, if the from Suphan Buri 50 was darker (lower L*)
peroxidase is inactivated, the polyphenol and more saturated (higher C*) than those of
oxidase that is the key enzyme related to the Singapore. However, the juice from Singapore
browning of sugarcane juice [14] would be variety was greener (higher h) than Suphan
ceased as well. Buri 50. These results indicate the color
The determination of the total solid features of juice from each sugarcane variety.
120 Chiang Mai J. Sci. 2011; 38(1)

Importantly, the sensory test disclosed that Buri 50 variety was chosen for the following
the flavor of juice from Suphan Buri 50 was experiments.
significantly preferred. As a result, the Suphan After the varieties comparison, the results

Table 2. The properties of sugarcane juice from Singapore and Suphan Buri 50 varieties.
Color Sensory test
Sugarcane variety Total solid result in
o
( Brix) pH L* C* h aspect of flavor
(7 = maximum)
Singapore 12.1 0.4a 5.3 0.1a 55.8 0.02 a 9.1 0.11a 101.0 0.05 a 4.2 1.2a
b a b b b b
Suphan Buri 50 19.6 0.2 5.0 0.1 44.2 0.03 23.8 0.02 91.3 0.02 5.3 1.2 b

Note: The color was measured in L* (lightness), C* (chroma) and h (hue).
Total solid, pH, L*, C*, h and sensory test results are mean standard deviation.
Means with the same superscript within same column are insignificant different (P < 0.05).

of two pretreatment methods, blanching in L*, C* and h values could be observed among
hot water and microwave heating are shown the samples pretreated by the steam blanching
in Table 3. There were 30 panelists for this and microwave heating. The darker color of
sensory evaluation. The peroxidase activity the juice from microwave-heated sugarcane
test revealed that the color change happening can be explained by the fast heating rate inside
in fresh juice from non-pretreated sugarcane the sugarcane stem occurring during the
faster and more intense than those of microwave treatment. This heat expedited the
pretreated samples. It means that the maillard reaction between the reducing sugar
peroxidase activities in the sugarcane were and amino acid in the stem leading to the
partially reduced by either blanching in hot browning or darker color [19]. For the juice
water or microwave heating. Furthermore, preparation in the UHT experiments, the
the color change for the peroxidase activity pretreatment by blanching sugarcane in hot
o
test in case of blanching the cane in hot water water at 80 C for 5 minutes was selected due
was in the comparable rate and intense to the to its ease of control, lower energy and
microwave heating. This result is similar to the equipment cost [16] but providing comparable
Moreno et al. [13] who found that the enzyme enzyme inactivation level and juice quality to
activities of strawberries after steam blanching the microwave pretreatment.
and microwave heating were decreased to the The experimental results of the four
similar levels. In terms of the total solid, pH UHT runs are presented in Table 4. The
and sensory, there was insignificant difference sensory evaluation in this part was performed
between juices squeezed from samples by 20 panelists. It was clear that the juice
pretreated by these two methods. Nonetheless, sterilized at 140 C for 4 seconds was preferred
the color of juice from microwave-heated to those of 135 oC for 10 seconds. Moreover,
sugarcane was slightly darker (lower L*) and the juice without sugar flavor additive acquired
greener (higher h) than those of hot-water the higher rating than the flavor-added juice.
blanched sugarcane. Likewise, Moreno et al. In addition, the color of UHT processed juice
[13] stated that merely small differences of significantly differed from the fresh
Table 3. The properties of sugarcane juice from different heat pretreatments.

Peroxidase activity test Total Color Sensory test result in aspect of flavor
Pretreatment results solid (7 = maximum)
(oBrix) pH
Chiang Mai J. Sci. 2011; 38(1)

The time Intensity level
duration to of color L* C* h Color Flavor Taste Sweetness Overall
change change (5 = liking
color (s) maximum)
Non-
10 5 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
pretreatment
(1) Blanching in
hot water 80 C 25 4 19.6 0.2a 5.0 0.1a 44.2 0.03a 23.8 0.02a 91.3 0.02a 5.2 1.1a 5.2 1.3a 5.3 1.3a 5.4 1.3a 5.4 1.2a
for 5 minutes
(2) Microwave
heating for 5 25 4 18.9 0.6a 5.3 0.1a 39.5 0.09b 23.1 0.03b 94.0 0.12b 5.7 1.0a 5.1 1.2a 5.4 1.1a 5.7 1.1a 5.6 1.0a
minutes
Note: N/A = Not applicable
The color was measured in L* (lightness), C* (chroma) and h (hue).
Total solid, pH, L*, C*, h and sensory test results are mean standard deviation.
Means with the same superscript within same column are insignificant different (P < 0.05).
121
122

Table 4. The properties of sugarcane juice from different UHT conditions.
UHT condition Total Color Sensory test result (9 = maximum)
Sample Sterilization Holding Adding solid pH Ap- Overall
No. Temperature time flavor ( oBrix) L* a* b* pearance Aroma Color Taste Texture liking
o
( C) (s)
1 140 4 No 12.1 0.4a 5.0 0.04 a 32.8 2.7 a,b 4.2 0.4a 19.2 0.5a 6.7 1.6a 6.9 1.7a 6.7 1.8a 6.9 1.7a 6.4 1.1a 7.1 1.4 a
a b a,b a b,c a,b b a,b a,b a
2 140 4 Yes 11.9 0.5 4.5 0.01 32.1 0.8 4.5 0.1 18.2 0.1 5.9 1.8 5.4 1.8 5.9 1.8 5.9 2.1 6.3 1.3 6.1 1.4 b
3 135 10 No 11.0 1.1a 5.0 0.10 a 30.6 1.5a 4.2 0.2a 18.6 0.5a,c 4.9 1.3 b 4.9 2.1 b 5.0 1.6 b 4.5 2.2c 5.8 1.3a 4.9 1.5c
4 135 10 Yes 11.8 0.4a 4.5 0.01b 30.6 2.3a 4.4 0.3a 17.6 0.5 b 5.1 1.6 b 5.4 2.3 b 5.2 1.4 b 5.3 2.1 b,c 5.6 1.2a 5.0 1.5c
a c b b c
5 Fresh juice No 11.8 0.5 5.2 0.05 34.6 0.3 2.9 0.1 18.4 0.1 N/A N/A N/A N/A N/A N/A

Note: N/A = Not applicable
The color was measured in L* (lightness), a* (redness) and b* (yellowness).
Total solid, pH, L*, a*, b* and sensory test results are mean standard deviation.
Means with the same superscript within same column are insignificant different (P < 0.05).
Chiang Mai J. Sci. 2011; 38(1)
Chiang Mai J. Sci. 2011; 38(1) 123

counterpart especially the redness (a*, +). Therefore, the flavor additive was deemed
The redness of UHT processed juice was unnecessary in this case.
higher than the fresh juice while the lightness
(L*, +) was lower. The explanation was that ACKNOWLEDGEMENTS
the heat during sterilization expedited the The authors would like to convey special
maillard reaction between the reducing sugar thank to the Commercial Research and
and amino acid in the juice leading to the Development Project Cooperated Between
browning and degreening [19]. Moreover the Government and Private Sector, the Office
degreening of UHT juice could be occurred of the Higher Education Commission,
by the decrease in chlorophyll content [2] Thailand and the T.N. Sugar Industry Co.Ltd.
during the sterilization. Also, it appeared that for the project grant.
the yellowness values (b*, +) were significantly
different between flavor-added and no REFERENCES
flavor-added samples. If deeming the total [1] Kadam U.S., Ghosh S.B., De S.,
solid, there was insignificant difference Suprasanna P., Devasagayam T.P.A. and
between samples. On the other hand, the Bapat V.A., Antioxidant Activity in
average pH of juice decreased from 5.2 to Sugarcane Juice and its Protective Role
the range between 4.5-5.0 after UHT process. against Radiation Induced DNA
This pH reduction went along with the Damage, Food Chem., 2008; 106: 1154-
findings of Venkatachalam et al. [24] and 1160.
Rustom et al. [25]. The decrease of pH was [2] Yusof S., Shian L.S. and Osman A.,
occurred due to the protein unfolding, Changes in Quality of Sugar-cane Juice
through denaturation by heat and release of upon Delayed Extraction and Storage,
protons [25]. Food Chem., 2000; 68: 395-401.
[3] Prasad K. and Nath N., Effect of Pre-
4. CONCLUSIONS treatments and Clarificants on Sugarcane
According to the results, it appeared that Juice Characteristics, Asian J. Chem., 2002;
the sugarcane varieties, heat pretreatment 14(2): 723-731.
methods and UHT conditions have significant
[4] Mao L.C., Xu Y.Q. and Que F.,
effects on the sugarcane juice quality. This Maintaining the Quality of Sugarcane
work illustrated that the sugarcane Suphan Juice with Blanching and Ascorbic Acid,
Buri 50 variety is more appropriate for juice Food Chem., 2007; 104: 740-745.
production than Singapore variety. Also, the
[5] Tang premsri W., Lairungreang C.,
heat pretreatment by blanching sugarcane in
o Tangpremsri T., Arree K. and Senanarong
hot water at 80 C for 5 minutes should be
N., Suphan Buri 50 Juice Cane Variety,
performed to diminish the enzyme activities Thai Agric. Res. J., 1997; 15(1): 66-73.
occurring during the juice processing and
storage. The higher sterilization temperature [6] Ozoglu H. and Bayindirli A., Inhibition
of Enzymic Browning in Cloudy Apple
but shorter holding time seemed to provide
Juice with Antibrowning Agents, Food
the better quality juice. If requiring F0 4, the
o Control, 2002; 13: 213-221.
UHT sterilization at 140 C for 4 seconds
could keep the sugarcane flavors in the [7] Margherita R. and Giussani E., Effect
product and provide the more favorable of Fruit Blanching on Phenolics and
o
juice than those of 135 C for 10 seconds. Radical Scavenging Activity of Highbush
124 Chiang Mai J. Sci. 2011; 38(1)

Blueburry Juice, Food Res. Int., 2003; 36: Polyphenol Oxidase (PPO) Activity of
999-1005. Sugarcane Juice (Saccharum officinarum Var,
Yellow Cane), J. Agr. Food Chem., 2002,
[8] Matsui K.N., Granado L.M., Oliveira
50: 1,615-1,618.
P.V. and Tadini C.C., Peroxidase and
Polyphenol Oxidase Thermal Inactivation [15] Vamos-Vigyazo L., Polyphenol Oxidase
by Microwaves in Green Coconut Water and Peroxidase in Fruits and Vegetables,
Simulated Solutions, LWT, 2007, 40: 852- CRC Cr. Rev. Food Sci., 1981; 15(5):
859. 49-127.
[9] Weemaes C.A., Ludikhuyze L.R., Broeck [16] Chua K.J. and Chou S.K., New Hybrid
I.V., Hendrickx M.E. and Tobback P.P., Drying Technologies; in Sun, D.W., ed.,
Activity, Electrophoretic Characteristics Emerging Technologies for Food Processing,
and Heat Inactivation of Polypheno- Elsevier Academic Press, California,
loxidases from Apples, Avocados, 2005; 536-551.
Grapes, Pears and Plums, LWT, 1998,
[17] Cano M.P., Marin M.A. and Fuster C.,
31: 44-49.
Freezing of Banana Slices: Influence of
[10] Terefe N.S., Yang Y.H., Knoerzer K., Maturity Level and Thermal Treatment
Buckow R. and Versteeg C., High prior to Freezing, J. Food Sci., 1990; 55:
Pressure and Thermal Inactivation 1070-1072.
Kinetics of Polyphenol Oxidase and
[18] Lewis M.J., Improvements in the
Peroxidase in Strawberry Puree, Innov.
Pasteurisation and Sterilisation of Milk;
Food Sci. Emerg. Tech., 2010, 11: 52-60.
in Smit, G., ed., Dairy Processing-Improving
[11] Schweiggert U., Schieber A. and Carle Quality, Woodhead Publishing Ltd.,
R., Inactivation of Peroxidase, Poly- Cambridge, 2003; 93.
phenoloxidase, and Lipoxygenase in
[19] Romero C., Morales F.J. and Jimenez-
Paprika and Chili Powder after
Perez S., Effect of Storage Temperature
Immediate Thermal Treatment of the
on Galactose Formation in UHT Milk,
Plant Material, Innov. Food Sci. Emerg. Tech.,
Food Res. Int., 2001; 34: 389-392.
2005, 6: 403-411.
[20] Chen G., Corvalan C., Campanella H.
[12] Olivera D.F., Vina S.Z., Marani C.M.,
and Haley T.A., An Improved Method
Ferreyra R.M., Mugridge A., CLee J.H.
to Estimate Temperatures and Lethality
and Shaves A.R. and Mascheroni R.H.,
During the Cooling Stage of Sterilized
Effect of Blanching on the Quality of
Cylindrical Cans, Food Bioprod. Process.,
Brussels Sprouts (Brassica oleracea L.
2005; 83(C1): 36-42.
gemmifera DC) after Frozen Storage, J. Food
Eng., 2008; 84: 148-155. [21] Skjoldebrand C. and Ohlsson T., A
Computer Simulation Program for
[13] Moreno J., Chiralt A., Escriche I. and
Evaluation of the Continuous Heat
Serra J.A., Effect of Blanching/Osmotic
Treatment of Particulate Food Products.
Dehydration Combined Methods on
Part 1: Design, J. Food Eng., 1993; 20:
Quality and Stability of Minimally
149-165.
Processed Strawberries, Food Res. Int.,
2000; 33: 609-616. [22] Lee J.H. and Singh R.K., Determination
of Lethality and Processing Time in
[14] Qudsieh H.Y.M., Yusof S., Osman A.
a Continuous Sterilization System
and Rahman R.A., Effect of Maturity
Containing Particulates, J. Food Eng., 1990;
on Chlorophyll, Tannin, Color, and
11: 67-92.
Chiang Mai J. Sci. 2011; 38(1) 125

[23] Whitaker J.R., Principles of Enzymology for [25] Rustom I.Y.S., Lopez-Leiva M.H. and
the Food Sciences, New York: Marcel Nair B.M., Nutritional, Sensory and
Dekker Inc., 1994; 543-577. Physicochemical Properties of Peanut
Beverage Sterilized under Two Different
[24] Venkatachalam N., McMahon D.J. and
UHT Conditions, Food Chem., 1996; 56(1):
Savello P.A., Role of Protein and Lactose
45-53.
Interactions in the Age Gelation of
Ultra-High Temperature Processed
Concentrated Skim Milk, J. Food Sci.,
1993; 59: 621-625.